Utilizing a Pellet Tube for Smoking Meat
For those who use an electrical smoker and want to have fixed smoke for five+ hours otherwise you use a pellet smoker and simply aren’t getting sufficient smoke taste, I’ve the answer for you!
A pellet tube stuffed with pellets and lit at one finish will present fixed smoke for five+ hours relying on it’s measurement and the way full you fill it with pellets.
A few of it’s possible you’ll be right here since you’ve already tried to make use of a pellet tube and may’t maintain the darn factor lit! Properly, I’ll present you the right way to repair that downside as properly.
- Pellet tube
- Pellets
- Torch/Lighting gadget
First, you will have a pellet tube. I exploit one which I discovered on Amazon actually low cost and it really works nice!
Additionally, you will want pellets and virtually any pellets will work. I usually use the Pit Boss model from Wally world as a result of they’re low cost and so they work properly within the smoke tube in addition to in my pellet people who smoke.
You may as well buy pellets on amazon however they may price greater than what you could find domestically. Your selection there!
Third and presumably most essential, you will have a propane or butane torch. I just like the bigger Bernzomatic torches like plumbers use however the smaller creme brûlée torches can even work simply nice.
Right here’s the torch I exploit which you could find at Wally World, HD or virtually every other retailer that sells {hardware} and instruments.
Fill the tube all the best way full with dry pellets.
Notice: I’ve been identified to microwave my pellets in a bowl for a minute or two earlier than inserting them within the tube to ensure they’re dry however that is simply one thing I do to ensure, it’s most likely not usually obligatory.
I have a tendency to put the smoke tube horizontally on a flat, fire-proof floor however I’ve seen some stand them straight up through the lighting process.
Which smoke tube place do you assume is healthier? Submit it within the remark part under.
Activate the torch and maintain the flame to the pellets for about 45 seconds to get them to burning actual good.
As soon as they’re burning, permit them to burn for round 7 minutes to create a very nice mattress of coals. This mattress of coals is likely one of the key parts that retains the pellets going for 4 to five hours unattended.
If the pellets are nonetheless burning after 7 minutes, blow out the flame and proceed on to the following step.
Each smoker is completely different and placement is one thing that varies from smoker to smoker. The 2nd key element to creating positive the smoke tube retains smoking for hours on finish is air.
The smoke tube should get a provide of air through a vent, gap, opening, and so on. in order that it may possibly proceed burning.
As an example, I typically use a smoke tube within the Reqtec pellet smoker. I place it straight on the grate all the best way to the left, proper subsequent to the probe entry gap and that offers it loads of air.
Within the Masterbuilt electrical people who smoke, the smoke tube will set on the underside rack proper subsequent to the woodchip chute. The chute must be open to permit air to enter and maintain the smoke tube going.
For those who don’t have a vent or opening, you may modify your smoker or grill to create an air inlet so long as this gained’t void your current guarantee.
For those who use a smoke tube in your smoker, let me know within the remark space under what place works for you in your smoker. Be sure you tell us what kind, mannequin, era, and so on. of smoker you’ve.
Notice: I like to recommend NOT utilizing the water pan when utilizing a smoke tube. The additional moisture within the smoker may mess with the smoke tube staying lit and this isn’t good. If doable, go away the water pan dry when utilizing a smoke tube.
- Make sure that the pellets are dry. For those who suspect the pellets are in the least damp, pour them right into a bowl and microwave them for a minute or two to assist dry them.
- Maintain the lighter/torch to the pellets for 45 seconds. This enables extra pellets to start out burning which will provide you with a greater mattress of coals to maintain the pellets burning contained in the smoker.
- Let the pellets burn uninterrupted for a minimum of 7 minutes to create that mattress of coals we talked about in #2 above.
- Make sure that the pellet tube is getting ample air. The pellets should get a gradual provide of oxygen to proceed burning for hours on finish. If the pellets are going out, they could be starved for air.
For much more smoke taste, you should use wooden chips in with the pellets.
I like to recommend NOT utilizing wooden chips solely however layering them. As an example, a layer of pellets, then a layer of wooden chips, adopted by one other layer of pellets and so forth and so forth.
Pellets are likely to burn extra cleanly than wooden chips and whereas this can be a wonderful thing about pellets, it additionally means the flavour will be much less robust than wooden chips.
I like to recommend inserting pellets as your final layer and that’s the layer that you just mild to create mattress of coals.
Give it a try to see what you assume.
In case you have different ideas for lighting the pellet tube and/or conserving it lit for hours on finish, tell us within the comments area under.
Order Jeff’s Rubs and Barbecue Sauce TODAY!
✅ My rubs and sauce would be the neatest thing you’ve ever tasted and it’s a nice technique to help what we do!
Notice: You may as well order the formulation for my rubs and sauce and make these your self at dwelling. Seize these HERE and obtain instantly.
